Shanghai Sales Centre:
Address: room 2406, greenbelt and Chuang building, 450 Cao Yang Road, Putuo District, Shanghai.
Mailbox: sales@jeffelcn.com
Tel: 021-62586212 0573-88222777
Fax: 021-62586271 0573-88222622
Website: m.seeleylakefloral.com/en
Process characteristics:
1.WASTE WATER OPTIMIZATION
Stable Effluent Quality; High Resistance to Water Quality Impact load test; Effluent Suspended Matter and Turbidity are close to zero; Direct Reuse; Realization of Waste Water Optimization
2.FLEXIBLE OPERATIONAL CONTROL
The efficient interception of membrane intercepts microorganisms completely in the bioreactor; complete separation of Hydraulic Retention Time (HRT) and Sludge Retention Time (SRT); Flexible operational control.
3.REDUCE LAND AND CIVIL CONSTRUCTION INVESTMENT
The Concentration of Membrane Pool’s Activated Sludge is 8000 ~ 12000 mg/L, which both spares the room for sedimentation basin and minimizes land occupation and construction investment. The occupied area is about 1/3 of the traditional process.
4.REPRODUCTION OF NITROBACTERIA
High systematic nitrification efficiency is beneficial to the retention and reproduction of nitrobacteria. Deamination and dephosphorization may also be realized if the mode of operation is changed.
5.IMPROVE THE DEGRADATION EFFICIENCY
The degradation efficiency of refractory organics can be enhanced greatly since the sludge age can be very long.
6.CAN ACHIEVE ZERO SLUDGE EMISSIONS
Operated under high volumetric loading, low sludge loading, long sludge age, the reactor yields extremely low residual sludge. Due to the infinite sludge age, theoretically zero-release of sludge can be achieved.
7.EASY OPERATION AND MANAGEMENT
PLC control of system brings a convenient operation and management process.
Zhejiang jeffel Environmental Science and Technology Co., Ltd.was specializes in the R&D, industry manufacture, engineering application and market promotion of the materials and products used for filtration, separation and purification. Since its inception, which has always focused on research and development to promote a variety of new materials and products were separated by filtration, the polymer separation membrane materials and equipment.
| MBR膜組件參數 | MBR Membrane Components Specifications | ||
性能 Performance | 設計通量 Design Flux | 10-25L/(m2·h)根據水質不同適當選取 Select According to Different Water Quality |
產水濁度 Produced Water Turbidity | ≤1NTU | |
| TSS | 測不出 | |
產水大腸桿菌 Escherichia Coli In Producing Water | 10FCU/100ml | |
污泥濃度 Mixed Liquid Suspended Solids（MLSS） | 4000—12000mg/L | |
規格 Specifications | 膜絲材質 Membrane Filament Material | PVDF材質（帶襯工藝） PVDF (with liner) |
內徑/外徑 Inside Diameter/outer Diameter | 1.0/2.2mm | |
粘結材料 Bonding Material | 聚氨酯/環氧樹脂 PU/Epoxy Resin | |
連接管材質 Connecting Pipe Material | ABS | |
平均孔徑 Mean Pore Size | 0.03um | |
接口尺寸 Size Of Interface | DN32/G1/2快插 | |
使用條件 Operating Condition | 工作溫度 Operating Temperature | 15—35℃ |
設計工作壓力 Design Operation Pressure | -80Kpa—0 | |
PH耐受范圍 Ph Tolerance Scope | 2-12 | |
曝氣量 Aeration Rate | 膜面積：2.5L/(m2·min) | |
設計反洗壓力 Design Backflush Pressure | 0.05-0.2Mpa | |
維護性清洗 Maintenance Cleaning | 清洗頻率 Cleaning Frequency | 1次/周 Once a week |
清洗時間 Cleaning Time | 30-60min/ time | |
清洗藥劑 Cleaning Agent | 次氯酸鈉 Sodium Hypochlorite: 200-500mg/L; 檸檬酸/草酸 Citric Acid:1000-2000mg/L |
恢復性清洗 Restorative Cleaning | 藥物清洗頻率 Cleaning Frequency by Pharmaceutical | 1次/3個月或跨膜壓差達到50Kpa時 Once three months or Trans-membrane Pressure reaches 50Kpa |
清洗時間 Cleaning Time | 1 次/6小時 Once 6 hours | |
清洗藥劑濃度 Cleaning Agent Concentration | 次氯酸鈉 Sodium Hypochlorite: 2000mg/L; 檸檬酸/草酸 Citric Acid: 2000-4000mg/L |
MW系列膜片信息 | Information of MW series Membrane
規格 Specifications | 膜面積 Membrane Area | 膜片有效長度 Membrane Effective Length /mm | 膜絲數量 Membrane Filament Quantity |
| MW12b | 12m2 | 1070 | 1560 |
| MW16b | 16m2 | 1480 | 1560 |
| MW20b | 20m2 | 1800 | 1560 |
| MW25b | 25m2 | 2290 | 1560 |
| MW36c | 36m2 | 1840 | 2880 |
| MW15d | 15m2 | 1500 | 1440 |
| MW18d | 18m2 | 1800 | 1440 |
| MW23d | 23m2 | 2300 | 1440 |
| MW33e | 33m2 | 1830 | 2660 |
WeChat 2D code
| Shanghai Sales Center: | |
 | Address:Room 2111, Greenland and Chuang Building, No. 450 Caoyang Road, Putuo District, Shanghai |
 | Email: sales@jeffelcn.com |
 | Tel: 021-62586212 |
 | Fax: 021-62586271 |
| Zhejiang production base: | |
| Add: No. 370, Century Avenue, Development Zone, Chongfu Town, Tongxiang, Zhejiang, China |
| Email: sales@jeffelcn.com |
| Tel: 0573-88222777 |
| Fax: 0573-88222622 |
